Batteries for battery powered cars are more environmentally friendly than expected

The investigation shows that if the power used to charge the battery is not derived from purely hydroelectric sources, then it is primarily the operation of the electric car, which has an environmental impact, exactly as is the case with conventionally fuelled automobiles. The size of the environmental footprint depends on which sources of power are used to "fuel" the e-mobile. The Li-ion battery itself has, in contrast, a limited effect on the LCA of the electric vehicle. This is contrary to initial expectations that the manufacture of the batteries could negate the advantages of the electric drive.

The environmental impact of batteries for electric vehicles

Battery powered electric cars are often promoted as the ideal solution to the challenges of future mobility, since they produce no exhaust gases in operation. Li-ion batteries have established themselves over competing lead-acid and nickel metal-hydride (NiMH) types because they are lighter and can store more energy. Li-ion batteries are also basically maintenance-free, display no memory effect (loss of capacity when repeatedly charged after partial discharge), have a low self-discharge rate and are regarded as safe and long-lived. For these reasons they find use in many products such as laptop computers. But are they also environmentally friendly?

Researchers at Empa's "Technology and Society Laboratory" decided to find out for sure. They calculated the ecological footprints of electric cars fitted with Li-ion batteries, taking into account all possible relevant factors, from those associated with the production of individual parts all the way through to the scrapping of the vehicle and the disposal of the remains, including the operation of the vehicle during its lifetime. Data with which to evaluate the rechargeable batteries was not available and had to be obtained specifically for this purpose. In doing so the researchers made intentionally unfavorable assumptions. One such was to ignore the fact that after use in a car, a battery might well be used in a stationary setting for other purposes. Other relevant LCA information was obtained from the "ecoinvent" database, managed by Empa. The electric vehicles evaluated were equivalent in size and performance to a VW Golf, and the power used to charge the batteries was assumed to be derived from sources representing an average European electricity mix.

A new petrol-engined car, meeting the Euro 5 emission regulations, was used for comparison. It consumes on average 5.2 liter per 100 kilometers when put through the New European Driving Cycle (NEDC), a value significantly lower than the European average. In this respect, therefore, the conventional vehicle belongs to the best of its class on the market.

More a question of the power source rather than the battery

The study shows that the electric car's Li-ion battery drive is in fact only a moderate environmental burden. At most only 15 per cent of the total burden can be ascribed to the battery (including its manufacture, maintenance and disposal). Half of this figure, that is about 7.5 per cent of the total environmental burden, occurs during the refining and manufacture of the battery's raw materials, copper and aluminium. The production of the lithium, in the other hand, is responsible for only 2.3 per cent of the total. "Lithium-ion rechargeable batteries are not as bad as previously assumed," according to Dominic Notter, coauthor of the study which has just been published in the scientific journal "Environmental Science & Technology."

The outlook is not as rosy when one looks at the operation of an electric vehicle over an expected lifetime of 150'000 kilometers. The greatest ecological impact is caused by the regular recharging of the battery, that is, the "fuel" of the e-car. "Refueling" with electricity sourced from a mixture of atomic, coal-fired and hydroelectric power stations, as is usual in Europe, results in three times as much pollution as from the Li-ion battery alone. It is therefore worth considering alternative power sources: If the electricity is generated exclusively by coal-fired power stations, the ecobalance worsens by another 13 per cent. If, on the other hand, the power is purely hydroelectric, then this figure improves by no less than 40 per cent.

The conclusion drawn by the Empa team: a petrol-engined car must consume between three and four liters per 100 kilometers (or about 70 mpg) in order to be as environmentally friendly as the e-car studied, powered with Li-ion batteries and charged with a typical European electricity mix.